火焰原子吸收光谱法测定锌精矿中铟

doi:10.13228/j.boyuan.issn1000-7571.011731

摘要
图/表
参考文献
相关文章 (15)

全文: PDF (842 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要锌精矿中铟含量是贸易结算的重要指标,准确测定锌精矿中铟含量具有重要的指导意义。以盐酸-氟化铵-硝酸-硫酸溶解样品,在盐酸(1+19)介质中,使用空气-乙炔火焰,以303.9 nm为测定波长,建立了火焰原子吸收光谱法测定锌精矿中0.002 0%～0.120%(质量分数,下同)铟的方法。溶样试验表明,对于碳含量较低的样品,采用20 mL盐酸-0.2 g氟化铵-5 mL硝酸-5 mL硫酸可将样品溶解完全;若溶样后溶液有黑渣,说明样品中碳含量较高,则需再继续加入2 mL高氯酸进行溶样。考察了锌基体对测定的影响。结果表明,当锌基体质量浓度大于3.25 mg/mL时,锌基体对测定的干扰较为显著;当锌基体质量浓度不大于3.25 mg/mL时,锌基体对测定的干扰可忽略。对于不同铟含量的样品,实验采用不同的方法进行处理以消除锌基体对测定的干扰。对于高含量的铟(0.050%~0.120%),采取溶样后将溶液体积稀释为原来的2倍后直接测定的方法;对于低含量的铟(0.002 0%~0.050%),须在溶样后先采用乙酸丁酯对铟进行萃取分离再进行测定。干扰试验表明,无论是测定高含量铟还是低含量铟,样品中的其他共存元素均不干扰测定;测定液中残留的少量硫酸和硝酸均对测定无干扰。实验表明,铟的质量浓度在0.50～10.00 μg/mL范围内与其对应的吸光度呈线性关系,相关系数为0.999 7,方法检出限为0.088 μg/mL,定量限为0.29 μg/mL。采用实验方法对锌精矿样品中的铟进行测定,结果表明,高、低铟含量水平的测定结果分别与萃取分离分光光度法或电感耦合等离子体原子发射光谱法(ICP-AES)基本一致,相对标准偏差(n=11)为2.1%～5.2%。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	左鸿毅

关键词 ：火焰原子吸收光谱法(FAAS), 锌精矿, 乙酸丁酯, 铟

Abstract：Indium content in zinc concentrate is an important index for trade settlement. The accurate determination of indium content in zinc concentrate has important guiding significance. The sample was dissolved with hydrochloric acid, ammonium fluoride, nitric acid, and sulfuric acid. A method for determination of indium content in range of 0.002 0%-0.120% (mass fraction, similarly hereinafter) in zinc concentrate was established by flame atomic absorption spectrometry (FAAS) at 303.9 nm with air-acetylene as flame and hydrochloric acid (1+19) as determination medium. The sample dissolution tests showed that the sample with relatively low carbon content could be fully dissolved with 20 mL of hydrochloric acid, 0.2 g of hydrochloric acid, 5 mL of nitric acid, and 5 mL of sulfuric acid. If there was black residue in solution, it indicated that the carbon content in sample was relatively high, and 2 mL of perchloric acid should be further added for sample dissolution. The influence of zinc matrix on determination was investigated. The results showed that the interference of zinc matrix with determination was relatively significant when the mass concentration of zinc matrix was higher than 3.25 mg/mL. The interference of zinc matrix with determination could be ignored when the mass concentration of zinc matrix was not higher than 3.25 mg/mL. For the samples with different indium contents, different treatment methods were used to eliminate the interference of zinc matrix with the determination. When the indium content was high (0.050%-0.120%), the volume of solution after sample dissolution was diluted to twice for direct determination. When the indium content was low (0.002 0%-0.050%), the extraction separation of indium by butyl acetate should be conducted before determination. The interference tests indicated that other coexisting elements in sample did not interfere with determination whether for determination of high content or low content of indium, and the residual sulfuric acid and nitric acid in test solution had no interference with determination. The experimental results showed that the mass concentration of indium in range of 0.50-10.00 μg/mL had linear relationship with its corresponding absorbance. The correlation coefficient was 0.999 7. The limit of detection and limit of quantification was 0.088 μg/mL and 0.29 μg/mL, respectively. The experimental method was applied to the determination of indium in zinc concentrate sample, and the results were consistent with those obtained by spectrophotometry after extraction separation or inductively coupled plasma atomic emission spectroscopy (ICP-AES) for the sample with high content or low content indium, respectively. The relative standard deviations (RSD, n=11) were between 2.1% and 5.2%.

Key words： flame atomic absorption spectrometry (FAAS) zinc concentrate butyl acetate indium

收稿日期: 2022-01-05

ZTFLH:	O657.31
	TF03+1

基金资助:国家标准制修订项目(国标委发[2020]37号20202894-T-610)

作者简介: 左鸿毅(1973—),女,高级工程师,大学本科,主要从事有色金属检测研究和标准制修订工作;E-mail:yqyq17881@sina.com

引用本文:

左鸿毅. 火焰原子吸收光谱法测定锌精矿中铟[J]. 冶金分析, 2022, 42(6): 37-44. ZUO Hongyi. Determination of indium in zinc concentrate by flame atomic absorption spectrometry. , 2022, 42(6): 37-44.

链接本文:

http://yjfx.chinamet.cn/CN/10.13228/j.boyuan.issn1000-7571.011731 或 http://yjfx.chinamet.cn/CN/Y2022/V42/I6/37

[1] 钟勇.乙酸丁酯萃取-苯基荧光酮-溴化十六烷基三甲基铵光度法测定化探样及冶金物料中微量铟[J].冶金分析,2001,21(6):55-57.
ZHONG Yong.Determination of butyl acetate extraction-phenyl fluoridone-hexametyl trimethylated ammonium bromide photometry in chemical probe samples and metallurgical materials[J].Metallurgical Analysis,2001,21(6):55-57.
[2] 北京矿冶研究总院测试研究所.有色冶金分析手册[M].北京:冶金工业出版社,2004:336-338.
[3] 王艳红.锌精矿中铟的极谱测定探讨[J].有色矿冶,2006,22(2):15-16.
WANG Yanhong.Measurement of indium in zinc concentrate[J].Non-ferrous Mining and Metallurgy,2006, 22(2):15-16.
[4] 杨德利.火焰原子吸收光谱法测定铅泥中的铟[J].湖南有色金属,2011,27(4):68-70.
YANG Deli.Determination of indium content in lead slime by flame atomic absorption spectrometry[J].Hunan Nonferous Metals,2011,27(4):68-70.
[5] 李颜君.火焰原子吸收法测定锌冶炼渣中的痕量铟[J].化学分析计量,2019,28(5):65-67.
LI Yanjun.Determination of trace indium in zinc smelting slag by flame atomic absorption method[J].Chemical Analysis and Meterage,2019,28(5):65-67.
[6] 周耀明.火焰原子吸收法测定铅锌冶炼物料中低含量铟[J].冶金分析,2002,22(1):48-49.
ZHOU Yaoming.Determination of indium in the smelting charge of lead and zinc material by flame AAS[J].Metallurgical Analysis,2002,22(1):48-49.
[7] 袁丽丽.火焰原子吸收光谱法测定再生锌原料中铟[J].冶金分析,2021,41(2):54-59.
YUAN Lili.Determination of indium in recycled zinc material by flame atomic absorption spectrometry[J].Metallurgical Analysis,2021,41(2):54-59.
[8] 孔凡丽.火焰原子吸收光谱法测定锡渣中的铟[J].中国无机分析化学,2015,5(2):70-72.
KONG Fanli.Determination of indium in tin slag by flame atomic absorption spectrometry[J].Chinese Journal of Inorganic Analytical Chemistry,2015,5(2):70-72.
[9] 吕佳,王光明,李辽沙.火焰原子吸收光谱法测定高炉尘中铟[J].冶金分析,2011,31(6):22-25.
LÜ Jia,WANG Guangming,LI Liaosha.Determination of trace indium in blast furnace dust by flame atomic absorption spectrometry[J].Metallurgical Analysis,2011,31(6):22-25.
[10] 叶新民.乙酸丁酯萃取-原子吸收光谱法测定烟灰中铟[J].广东化工,2017,44(14):245-246.
YE Xinmin.AAS determination of indium in cigarette ash after extraction with butyl acetate[J].Guangdong Chemical Industry,2017,44(14):245-246.
[11] 高小飞,倪文山,孙晓燕,等.乙酸丁酯萃取-电感耦合等离子体原子发射光谱法测定钨矿石中铟[J].理化检验(化学分册),2012,48(10):1181-1183.
GAO Xiaofei,NI Wenshan,SUN Xiaoyan,et al.ICP-AES determination of indium in tungsten ore after extraction with butyl acetate[J].Physical Testing and Chemical Analysis (Part B:Chemistry Analysis),2012,48(10):1181-1183.
[12] 马丽.电感耦合等离子体发射光谱法测定锌精矿中的铟[J].中国无机分析化学,2013,3(2):50-52.
MA Li.Determination of indium in zinc concentrate by inductively coupled plasma atomic emission spectrometry[J].Chinese Journal of Inorganic Analytical Chemistry,2013,3(2):50-52.
[13] 苏春风.电感耦合等离子体原子发射光谱法(ICP-AES) 测定再生锌原料中铜、铅、铁、铟、镉、砷、钙、铝[J].中国无机分析化学,2016,6(1):53-58.
SU Chunfeng.Determination of copper,lead,iron,indium,cadmium,arsenic,calcium and aluminum contents in regenerated zinc materials by inductively coupled plasma emission spectrometry[J].Chinese Journal of Inorganic Analytical Chemistry,2016,6(1):53-58.
[14] 胡胭脂.ICP-AES法同时测定锌精矿、锗渣中镓铟锗[J].湖南有色金属,2015,31(1):74-77.
HU Yanzhi.Simultaneous determination of gallium, indium and germanium in zinc concentrate and germanium slag by ICP-AES[J].Hunan Nonferous Metals,2015,31(1):74-77.
[15] 廖述纯,满瑞林,余国珍.物料中不同含量铟的测定[J].有色冶炼,2003,32(4):35-38.
LIAO Shuchun,MAN Ruilin,YU Guozhen.Determination of the different contents of indium in the material[J].Non-ferrous Smelting,2003,32(4):35-38.
[16] 武明丽,叶新民,曾艳,等.乙酸丁酯萃取-EDTA滴定法测定铟阳极泥中高含量铟[J].冶金分析,2017,37(1):47-51.
WU Mingli,YE Xinmin,ZENG Yan,et al.Determination of butyl acetate extraction-titration by EDTA[J].Metallurgical Analysis,2017,37(1):47-51.
[17] 国家技术监督局.GB/T 2469—1996 硫铁矿及硫精矿中碳含量的测定烧碱石棉重量法[S].北京:中国标准出版社,1999.
[18] 中华人民共和国质量监督检验检疫总局,中国国家标准化管理委员会.GB/T 8151.20—2012 锌精矿化学分析方法第20部分铜、铅、锌、铁、砷、镉、钙、镁量的测定电感耦合等离子体原子发射光谱法[S].北京:中国标准出版社,2012.