超声萃取-气相色谱法测定刹车片摩擦层中游离苯酚

doi:10.13228/j.boyuan.issn1000-7571.012359

摘要
图/表
参考文献
相关文章 (8)

全文: PDF (0 KB) HTML (1 KB)
输出: BibTeX | EndNote (RIS)

摘要刹车片摩擦层中游离苯酚会挥发进入空气中从而污染人们的生活环境,因此需要准确测定并控制其含量。将样品装进洁净的冷冻粉碎钢瓶内,通过液氮冷冻粉碎为粒径0.075~0.150 mm的粉末状固体,称取0.5~1.0 g粉末状固体,用乙醇超声萃取30 min,定容后取上层清液,用0.45 μm滤膜过滤,采用HP-INNOWax毛细管色谱柱进行分离后用气相色谱法进行测定,实现了气相色谱法对刹车片摩擦层中游离苯酚的测定。实验表明,游离苯酚在2.0~200 mg/L质量浓度范围内与其对应的色谱峰面积呈线性关系,线性相关系数为0.999 5,方法定量限为10 mg/kg。按照实验方法测定4个刹车片摩擦层样品中游离苯酚的含量,结果表明,游离苯酚测定结果的相对标准偏差(RSD,n=6)不大于3%。在样品中分别添加5.0、10.0、30.0 mg/L苯酚标准工作液进行加标回收试验,回收率为86%~107%。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	余建龙
	刘健斌
	李全忠
	卢焯冬
	房兆龙
	吴长俊

关键词 ：气相色谱法, 毛细色谱柱, 刹车片, 摩擦层, 游离苯酚

Abstract：Free phenol in the friction layer of brake pads will volatilize into the air and pollute people's living environment,so it is necessary to accurately determine and control its content. After the sample was transferred into a clean cryogenic grinding steel cylinder, it was frozen and pulverized into a powdered solid with particle size of 0.075-0.150 mm by liquid nitrogen. 0.5-1.0 g of solid powder was weighed and treated by ultrasonic extraction for 30 min with ethanol. After dilution to the mark, the supernatant liquor was filtered with 0.45 μm membrane. Then it was separated with HP-INNOWax capillary column and determined by gas chromatography. Consequently, the determination of free phenol in the friction layer of brake pads was realized by gas chromatography. The results showed that the concentration of free phenol in range of 2.0-200 mg/L had a linear relationship with its corresponding chromatographic peak area. The linear correlation coefficient was 0.999 5, and the limit of quantification of method was 10 mg/kg. The contents of free phenol in 4 friction layer samples of brake pad were determined according to the proposed method. The results showed that the relative standard deviations (RSD, n=6) of determination results of free phenol were less than 3%. 5.0, 10.0 and 30.0 mg/L of phenol standard working solution was added into sample for recovery tests. The recoveries were between 86% and 107%.

Key words： gas chromatography capillary column brake pad friction layer free phenol

收稿日期: 2023-10-18

ZTFLH:	O657.7+1
	U463.55

基金资助:国家重点研发计划项目(2021YFF0602603)

作者简介: 余建龙(1987-),男,工程师,大学本科,主要研究方向为有机化学分析;E-mail:lonwell@163.com

引用本文:

余建龙, 刘健斌, 李全忠, 卢焯冬, 房兆龙, 吴长俊. 超声萃取-气相色谱法测定刹车片摩擦层中游离苯酚[J]. 冶金分析, 2024, 44(6): 44-48. YU Jianlong, LIU Jianbin, LI Quanzhong, LU Zhuodong, FANG Zhaolong, WU Changjun. Determination of free phenol in friction layer of brake pad by gas chromatography with ultrasonic extraction. , 2024, 44(6): 44-48.

链接本文:

http://yjfx.chinamet.cn/CN/10.13228/j.boyuan.issn1000-7571.012359 或 http://yjfx.chinamet.cn/CN/Y2024/V44/I6/44

[1] 李吉明,薛纪东,钟汉荣.一种汽车刹车片胶粘剂的研制及性能研究[J].粘接,2013,34(2):53-55.
LI Jiming,XUE Jidong,ZHONG Hanrong.Preparation and performance of an automobile brake pad adhesive[J].Adhesion,2013,34(2):53-55.
[2] 孙建生,吴春芝,李吉宏,等.J-671汽车刹车片胶粘剂的研究[J].中国胶粘剂,2000(2):22-24.
SUN Jiansheng,WU Chunzhi,LI Jihong,et al.The study on J-671 adhesive for automobile brake[J].China Adhesives,2000(2):22-24.
[3] 孙喜梅.汽车刹车片粘接工序及其质量检测探究[J].粘接,2021,48(12):151-154.
SUN Ximei.Research on adhesive process and quality inspection of automobile brake pad[J].Adhesion,2021,48(12):151-154.
[4] 中华人民共和国化学工业部.HG 5—1342—1980酚醛树脂中游离苯酚含量测定方法[S].北京:中国标准出版社,1980.
[5] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会.GB/T 7130—2016塑料酚醛模塑制品游离酚的测定碘量法[S].北京:中国标准出版社,2016.
[6] 董清木,林睿,赖莺,等.高效液相色谱法测定建筑用胶黏剂中的游离苯酚[J].广州化学,2013,38(3):30-33.
DONG Qingmu,LIN Rui,LAI Ying,et al.Determination of free phenol in phenolic resin adhesives used in buliding by HPLC[J].Guangzhou Chemistry,2013,38(3):30-33.
[7] 符冠烨,陈文山,周光明,等.反相高效液相色谱法测定热塑性酚醛树脂中苯酚的含量[J].西南师范大学学报(自然科学版),2002(3):361-363.
FU Guanye,CHEN Wenshan,ZHOU Guangming,et al.Determination of phenol in thermoplastic phenolic resin by high performance liquid chromatography[J].Journal of Southwest China Normal University(Natural Science),2002(3):361-363.
[8] 柴莉娜,杨贤娜,梁诗敏.UV法快速测定朵贝尔氏溶液中苯酚的含量[J].广东化工,2022,49(13):173-175.
CHAI Li'na,YANG Xianna,LIANG Shimin.Rapid determination of phenol in dobell's solution by UV spectrophotometry[J].Guangdong Chemical Industry,2022,49(13):173-175.
[9] 李敏,赵威威,甘雪菲,等.紫外分光光度法测定酚醛树脂中游离苯酚含量[J].木材工业,2014,28(6):32-34.
LI Min,ZHAO Weiwei,GAN Xuefei,et al.Determination of free phenol content in phenol-foemaldehyde resin by ultraviolet spectrophotometry[J].Chinese Journal of Wood Science and Technology,2014,28(6):32-34.
[10] 钟崇泳.胶粘剂及其树脂中游离苯酚含量测定方法[J].广东化工,2008,35(8):130-132.
ZHONG Chongyong.Testing methods for afhesives and their resting method for determination of free phenol content [J].Guangdong Chemical Industry,2008,35(8):130-132.
[11] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会.GB/T 30773—2014气相色谱法测定酚醛树脂中游离苯酚含量[S].北京:中国标准出版社,2014.
[12] 曹志祥,叶元坚,郭永翔,等.气相色谱法测定硬质酚醛泡沫制品中游离苯酚含量[J].广东化工,2012,39(8):27-28.
CAO Zhixiang,YE Yuanjian,GUO Yongxiang,et al.Determination of residual phenol in rigid phenolic foam by gas chromatography[J].Guangdong Chemical Industry,2012,39(8):27-28.
[13] Bekhterev V N.Rapid gas-chromatographic determination of phenol and cresols in water by extractive freezing-out[J].Journal of Analytical Chemistry,2023,78(6):776-782.
[14] Kim Aleksandr L,Dubrovskii Alexey V,Musin Egor V,et al.Determination of phenol with peroxidase immobilized on CaCO₃[J].International Journal of Molecular Science,2023,24(7):6766.
[15] WANG Yuanzhe,R G Compton.An approach to the electroanalysis of electrode passivating analytes: the determination of phenol[J].ChemElectroChem,2020,7(16):3508-3516.